Product ID:RHODORSIL FLUID 47V100 THROUGH 2500000
MSDS Date:09/04/1996
FSC:9150
NIIN:00-269-8246
Status Code:A
MSDS Number: CLLZW

Emergency Phone: (800) 424-9300

Info Phone: 609-860-4000/800-356-7560

Cage: LO755

Telephone: 215-743-8200

Cage: 2B613

POLY(DIMETHYL)SILOXANES

CAS: 63148-62-9

RTECS: JT6484500

LD50 LC50 Mixture:NO DATA PROVIDED BY MANUFACTURER
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE-EYE: NON-IRRITATING. MAY CAUSE
FOREIGN BODY IRRITATION ONLY. ACUTE SKIN: NON-IRRITATING. LOW ACUTE
DERMAL TOXICITY. ACUTE-INHALATION: INHALATION NOT LIKELY. ACUTE
INGESTION: LOW ACUTE ORAL TOXIC ITY. CHRONIC EFFECTS: THIS PRODUCT
DOES NOT CONTAIN ANY INGREDIENT DESIGNATED BY IARC, NTP, ACGIH OR
OSHA AS PROBABLE OR SUSPECTED HUMAN CARCINOGENS.
Explanation of Carcinogenicity:THIS PRODUCT DOES NOT CONTAIN ANY
INGREDIENT DESIGNATED BY IARC, NTP, ACGIH OR OSHA AS PROBABLE OR
SUSPECTED HUMAN CARCINOGENS.
Effects of Overexposure:ACUTE-EYE: NON-IRRITATING. MAY CAUSE FOREIGN
BODY IRRITATION ONLY. ACUTE SKIN: NON-IRRITATING. LOW ACUTE DERMAL
TOXICITY. ACUTE-INHALATION: INHALATION NOT LIKELY. ACUTE INGESTION:
LOW ACUTE ORAL TOXIC ITY.
Medical Cond Aggravated by Exposure:NO SPECIFIC INFORMATION FOUND.

First Aid:EYE: IN CASE OF CONTACT, IMMEDIATELY ABSORB EXCESS WITH CLEAN
ABSORBENT CLOTH OR COTTON. THEN, HOLD EYELIDS OPEN & FLUSH WITH A
STEADY, GENTLE STREAM OF WATER FOR AT LEAST 15 MINUTES. SEEK
MEDICAL ATT ENTION IF IRRITATION DEVELOPS OR PERSISTS OR IF VISUAL
CHANGES OCCUR. SKIN: IMMEDIATELY WIPE EXCESS MATERIAL OFF SKIN WITH
A DRY CLOTH; THEN WASH SKIN WITH PLENTY OF SOAP & WATER. SEEK
MEDICAL ATTENTI ON IF IRRITATION DEVELOPS OR PERSISTS. INHALATION:
INHALATION IS NOT AN EXPECTED ROUTE OF EXPOSURE. IF RESPIRATORY
IRRITATION OR DISTRESS OCCURS REMOVE VICTIM TO FRESH AIR. SEEK
MEDICAL ATTENTION IF RESPIRATORY IRRITATION OR DISTRESS

Flash Point Method:TCC
Flash Point:>300.C, 572.F
WILL BURN
Lower Limits:NO DATA
Upper Limits:NO DATA
Extinguishing Media:DRY CHEMICAL, FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR NIOSH/MSHA APPROVED
SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING.
COOL CONTAINERS EXPOSED TO FIRE WITH WATER.
Unusual Fire/Explosion Hazard:PRODUCT WILL BURN UNDER FIRE CONDITIONS.
HAZARDOUS DECOMPOSITION MATERIALS (UNDER FIRE CONDITIONS):
FORMALDEHYDE, OXIDES OF CARBON, SILICA (CRYSTALLINE).

Spill Release Procedures:WEAR APPROPRIATE PROTECTIVE GEAR FOR THE
SITUATION. SPILLED MATERIAL MAY MAKE THE FLOOR SLIPPERY. DO NOT
LEAVE TRACES OF PRODUCT ON FLOORS, LADDERS, ETC., AS THIS MAY
PRESENT A SLIPPING HAZARD. ABSORB WITH AN INERT ABSORBENT. SCRAPE
UP AND PLACE IN APPROPRIATE CLOSED CONTAINER. CLEAN UP RESIDUAL
MATERIAL WITH AN APPROPRIATE SOLVENT LIKE PAINT THINNER OR MINERAL
SPIRITS, PROVIDED THAT THERE IS GOOD
Neutralizing Agent:NO DATA PROVIDED BY MANUFACTURER

Handling and Storage Precautions:MINIMUM / MAXIMUM STORAGE
TEMPERATURES: 5 TO 25C (41 TO 77F). AVOID DIRECT OR PROLONGED
CONTACT WITH SKIN AND EYES. STORE IN TIGHTLY CLOSED CONTAINERS.
RECOMMENDED CONTAINER MATERIAL: EPOXY-COATED STE EL, ORDINARY
STEEL, POLYETHYLENE. STORE IN AN AREA THAT IS DRY, WELL-VENTILATED.
Other Precautions:ANY CONTAINERS OR EQUIPMENT USED SHOULD BE
DECONTAMINATED IMMEDIATELY AFTER USE.

Respiratory Protection:WHEN RESPIRATORS ARE REQUIRED, SELECT NIOSH/MSHA
APPROVED EQUIPMENT BASED ON ACTUAL OR POTENTIAL AIRBORNE
CONCENTRATIONS AND IN ACCORDANCE WITH THE APPROPRIATE REGULATORY
STANDARD AND/OR INDUSTRIAL RE COMMENDATIONS. FOR REASONABLY
FORESEEABLE INDUSTRIAL AND USES OF THIS MATERIAL, RESPIRATORY
PROTECTION SHOULD NOT BE NCECESARY.
Ventilation:GENERAL AREA DILUTION/EXHAUST VENTILATION.
Protective Gloves:SKIN CONTACT SHOULD BE MINIMIZED THROUGH USE OF
GLOVES
Eye Protection:EYE AND FACE PROTECTION REQUIREMENTS WILL VARY DEPENDENT
UPON WORK ENVIRONMENT
Other Protective Equipment:SUITABLE LONG-SLEEVED CLOTHING (I.E., SHIRTS
AND PANTS). CONSIDERATION MUST BE GIVEN BOTH TO DURABILITY AS WELL
AS PERMEATION RESISTANCE.
Work Hygienic Practices:DO NOT STORE, USE &/OR CONSUME FOODS,
BEVERAGES, TOBACCO PRODUCTS, OR COSMETICS IN AREAS WHERE THIS
MATERIAL IS STORED. WASH HANDS & FACE CAREFULLY BEFORE EATING,
DRINKING, USING TOBACCO.
Supplemental Safety and Health
THESE RECOMMENDATIONS PROVIDE GENERAL GUIDANCE FOR HANDLING THIS
PRODUCT. BECAUSE SPECIFIC WORK ENVIRONMENTS & MATERIAL HANDLING
PRACTICES VARY, SAFETY PROCEDURES SHOULD BE DEVELOPED FOR EACH
INTENDED APPLICATION. WHILE DEVELOPING SAFEHANDLING PROCEDURES, DO
NOT OVERLOOK THE NEED TO CLEAN EQUIPMENT AND PIPING SYSTEMS

HCC:V5
Boiling Pt:B.P. Text:NOT AVAILABLE
Melt/Freeze Pt:<-54.C, -65.2F
Vapor Pres:<0.01 MMHG @200C (392F)
Spec Gravity:>0.96 @ 25C(77F)
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR, VISCOUS LIQUID; ODORLESS.

Stability Indicator/Materials to Avoid:YES
STRONG BASES, STRONG ACIDS, STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, OPEN FLAME, SPARK.
Hazardous Decomposition Products:DECOMPOSITION TYPE:
THERMAL-DIMETHYLCYCLOSILOXANES, METHYLPHENYLCYCLOSILOXANES.
DECOMPOSITION TYPE: OXIDATIVE/THERMAL: FORMALDEHYDE
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:CHEMICAL ADDITIONS, PROCESSING OR OTHERWSE
ALTERING THIS MATERIAL MAY MAKE THE WASTE MANAGEMENT INFORMATION
PRESENTED IN THIS MSDS INCOMPLETE, INACCURATE OR OTHERWISE
INAPPROPRIATE. STATE & LOCAL REQU IREMENTS FOR WASTE DISPOSAL MAY
BE MORE RESTRICTIVE OR OTHERWISE DIFFERENT FROM FEDERAL LAWS &
REGUL ATIONS. EPA HAZARDOUS WASTE: NO.

Toxicological Information:TOXICOLOGICAL INFORMATION AND INTERPRETATION:
EYE-EYE IRRITATION, RABBIT; NON-IRRITATING. SKIN: SKIN IRRITATION,
RABBIT: NON-IRRITATING. LD50 >5000 MG/M3, RAT. NO DEATHS OBSERVED.
ACUTE RESPIRATORY IR RITATION: NO TEST DATA FOUND FOR PRODUCT.
ACUTE INHALATION TOXICITY: NO TEST DATA FOUND FOR PRODUCT. ACUTE
ORAL TOXICITY: LD50 > 5000 MG/KG, RAT. NO DEATHS OBSERVED. CHRONIC
TOXICITY: UNDER CERTAIN CO NDITIONS, THIS PRODUCT MAY GENERATE
FORMALDEHYDE. FORMALDEHYDE IS LISTED AS A POTENTIAL HUMAN
CARCINOGEN BY IARC, OSHA AND ACGIH.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:ECOTOXICOLOGICAL INFORMATION: NO DATA FOUND FOR PRODUCT.
CHEMICAL FATE INFORMATION: NO DATA FOUND FOR PRODUCT.

Transport Information:NOT REGULATED.

SARA Title III Information:SARA TITLE III HAZARD CLASSES: FIRE HAZARD -
NO. REACTIVE HAZARD - NO. RELEASE OF PRESSURE - NO. ACUTE HEALTH
HAZARD - NO. CHRONIC HEALTH HAZARD - NO.
Federal Regulatory Information:TSCA INVENTORY STATUS: ALL FUNCTIONAL
COMPONENTS OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY.
State Regulatory Information:THIS PRODUCT DOES NOT CONTAIN ANY
COMPONENTS THAT ARE REGULATED UNDER CALIFORNIA PROPOSITION 65.